Stability of thin quasi-crystalline Ti-Zr-Ni films and related crystalline phases under low-energy transient plasma irradiation

• Дата: 2022
• Автори: Malykhin, S.V., Kondratenko, V.V., Makhlai, V.A., Garkusha, I.E., Kopylets, I.A., Borisov, Yu.S., Herashchenko, S.S., Surovitskiy, S.V., Borisova, S.S.
• Формат: Стаття
• Мова: English
• Опубліковано: Національний науковий центр «Харківський фізико-технічний інститут» НАН України 2022
• Назва видання: Problems of Atomic Science and Technology
• Теми: Low temperature plasma and plasma technologies
• Онлайн доступ: http://dspace.nbuv.gov.ua/handle/123456789/195908
• Назва журналу: Digital Library of Periodicals of National Academy of Sciences of Ukraine
• Цитувати: Stability of thin quasi-crystalline Ti-Zr-Ni films and related crystalline phases under low-energy transient plasma irradiation / S.V. Malykhin, V.V. Kondratenko, V.A. Makhlai, I.E. Garkusha, I.A. Kopylets, Yu.S. Borisov, S.S. Herashchenko, S.V. Surovitskiy, S.S. Borisova // Problems of Atomic Science and Technology. — 2022. — № 6. — С. 143-148. — Бібліогр.: 30 назв. — англ.

The properties of Ti41Zr38.3Ni20.7 thin films under radiation-thermal action of hydrogen plasma with a surface heat load of 0.2 MJ/m² was studied at the QSPA Kh-50 quasi-stationary plasma accelerator (NSC KIPT). The phase composition, structural state, and surface morphology were studied using X-ray diffraction and scanning electron microscopy. It was found that the quasicrystalline phase and related crystalline phases, the Laves phase, the α-solid solution, and the 2/1 phase of the Ti-Zr-Ni approximant crystal were stable under irradiation with up to 20 hydrogen plasma pulses. The phase composition did not change. It is shown that the changes in the coatings mainly manifest themselves as changes in the substructure of the observed phases. With an increase in the plasma exposure dose, the structure of the quasicrystalline icosahedral phase improves, and the size of the coherence regions increases. In the films consisting of crystalline phases, a partial phase transformation is observed with a redistribution of components between the 2/1 phase of the approximant crystal and the α-solid solution phase. It was found that thin films of the Ti-Zr-Ni system containing a quasicrystalline icosahedral phase, irradiated with radiation-thermal plasma pulses, are less prone to cracking than coatings with crystalline phases of the same system.